Performance characteristics of single-cylinder spark-ignition engine and its pollutant emissions by using methanol and ethanol fuel blended with gasoline

Document Type : Original Article

Authors

1 Department of Environmental Health Engineering, Health Sciences Research Center, Faculty of Health, Mazandaran University of Medical Sciences, Sari, Iran.

2 Student of Environmental Health Engineering, Student Research Committee, Faculty of Health, Mazandaran University of Medical Sciences, Sari, Iran.

Abstract

Introduction:Increasing air pollution is one of the problems of living in large cities. Motor vehicles are the main source of emissions of these pollutants. Petroleum derivatives, especially gasoline, are the most important fuel for internal combustion engines. The fuel consumption of these engines causes excess emissions of pollutants such as carbon monoxide, carbon dioxide, sulfur oxides and nitrogen oxides. Therefore, the use of an alternative fuel seems necessary. The aim of this study was to investigate performance characteristics of single-cylinder spark-ignition engine and its pollutant emissions by using methanol and ethanol fuel blended with gasoline.
Methods: In this study, Honda single-cylinder four-stroke engine was used. Gasoline was prepared from the locations of the National Oil Distribution Company and separately mixed with methanol and ethanol in different proportions. The tests were performed at 2 engine speeds including 2000 and 4000 rpm. Obtained data were analyzed by SPSS 16.
Results:The results showed that the combination of methanol fuel with gasoline in variable proportions produced less pollutant at low engine speed compared to that of ethanol fuel. Similarly, this result was also observed at high engine speed. Therefore, methanol fuel is more suitable as an alternative to fossil fuels such as gasoline in terms of emission of pollutants. Regarding the average amount of total emissions resulted from consumption of alternative fuels combined with gasoline, it can be said that the amount of pollutant production decreases with increasing methanol and ethanol content.
Conclusion: The use of methanol and ethanol as an alternative fuel to gasoline in automobiles reduces pollutant emissions Therefore, the problem of pollutants produced by gasoline engines can be significantly reduced through replacing gasoline by ethanol and methanol, and this replacement can result in improvement of health and satisfaction of the people.

Keywords


 
1.   Kwanchareon P, Luengnaruemitchai A, Jai-In S. Solubility of a diesel–biodiesel–ethanol blend, its fuel properties, and its emission characteristics from diesel engine. Fuel. 2007;86(7-8):1053-61.
2.   Kumar MS, Kerihuel A, Bellettre J, Tazerout M. Ethanol animal fat emulsions as a diesel engine fuel–part 2: engine test analysis. Fuel. 2006;85(17-18):2646-52.
3.   Qi D, Chen H, Geng L, Bian Y. Effect of diethyl ether and ethanol additives on the combustion and emission characteristics of biodiesel-diesel blended fuel engine. Renewable energy. 2011;36(4):1252-8.
4.   Sheehan J, Aden A, Paustian K, Killian K, Brenner J, Walsh M, et al. Energy and environmental aspects of using corn stover for fuel ethanol. Journal of Industrial Ecology. 2003;7(3‐4):117-46.
5.   Xing-cai L, Jian-Guang Y, Wu-Gao Z, Zhen H. Effect of cetane number improver on heat release rate and emissions of high speed diesel engine fueled with ethanol–diesel blend fuel. Fuel. 2004;83(14-15):2013-20.
6.   Hansen AC, Zhang Q, Lyne PW. Ethanol–diesel fuel blends––a review. Bioresource technology. 2005;96(3):277-85.
7.   Rakopoulos D, Rakopoulos C, Kakaras E, Giakoumis E. Effects of ethanol–diesel fuel blends on the performance and exhaust emissions of heavy duty DI diesel engine. Energy Conversion and Management. 2008;49(11):3155-62.
8.   Shi X, Yu Y, He H, Shuai S, Wang J, Li R. Emission characteristics using methyl soyate–ethanol–diesel fuel blends on a diesel engine. Fuel. 2005;84(12-13):1543-9.
9.   Ajav E, Singh B, Bhattacharya T. Experimental study of some performance parameters of a constant speed stationary diesel engine using ethanol–diesel blends as fuel. Biomass and Bioenergy. 1999;17(4):357-65.
10.  Yüksel F, Yüksel B. The use of ethanol–gasoline blend as a fuel in an SI engine. Renewable energy. 2004;29(7):1181-91.
11.  Shi X, Pang X, Mu Y, He H, Shuai S, Wang J, et al. Emission reduction potential of using ethanol–biodiesel–diesel fuel blend on a heavy-duty diesel engine. Atmospheric Environment. 2006;40(14):2567-74.
12.  Zhu L, Cheung C, Zhang W, Huang Z. Combustion, performance and emission characteristics of a DI diesel engine fueled with ethanol–biodiesel blends. Fuel. 2011;90(5):1743-50.
13.  Shahir S, Masjuki H, Kalam M, Imran A, Fattah IR, Sanjid A. Feasibility of diesel–biodiesel–ethanol/bioethanol blend as existing CI engine fuel: An assessment of properties, material compatibility, safety and combustion. Renewable and Sustainable Energy Reviews. 2014;32:379-95.
14.  Koç M, Sekmen Y, Topgül T, Yücesu HS. The effects of ethanol–unleaded gasoline blends on engine performance and exhaust emissions in a spark-ignition engine. Renewable energy. 2009;34(10):2101-6.
15.  Ometto AR, Hauschild MZ, Roma WNL. Lifecycle assessment of fuel ethanol from sugarcane in Brazil. The international journal of life cycle assessment. 2009;14(3):236-47.